Field Maintenance Manual Tools List For Engineer Mission Module - Water Distributor

CHAPTER 1. GENERAL INFORMATION, EQUIPMENT DESCRIPTION, AND THEORY OF OPERATION
GENERAL INFORMATION
DESTRUCTION OF ARMY MATERIAL TO PREVENT ENEMY USE
Table 1. List of Abbreviations
Table 1. List of Abbreviations - Continued.
Table 2. Warning Icons
Table 2. Warning Icons - Continued.
Table 2. Warning Icons - Continued.
Table 2. Warning Icons - Continued.
Table 2. Warning Icons - Continued.
EQUIPMENT DESCRIPTION AND DATA
Table 1. Equipment Data
Table 1. Equipment Data - Continued.
THEORY OF OPERATION
CHAPTER 2. TROUBLESHOOTING PROCEDURES
GENERAL TROUBLESHOOTING INSTRUCTIONS
TROUBLESHOOTING RULES
TROUBLESHOOTING SYMPTOM INDEX - FIELD MAINTENANCE
TROUBLESHOOTING SYMPTOM INDEX - Continued
TROUBLESHOOTING SYMPTOM INDEX - Continued
ENGINE DOES NOT CRANK
Figure 1. Engine Off/Battery Drain Indicator - Step 1.
Figure 3. Battery Cables - Step 3.
Figure 4. Battery Terminals - Step 4.
Figure 5. Wire Connections - Step 5.
Figure 6. Starter Relay Wire Connections - Step 6.
Figure 7. Starter Solenoid Positive Terminal - Step 7.
Figure 8. Starter Motor Ground Wire - Step 8.
Figure 9. Starter Solenoid White Wire - Step 9.
Figure 11. Starter Relay Blue Wire - Step 10.
Figure 13. Starter Relay White Wire - Step 11.
Figure 14. Starter Solenoid White Wire - Step 11.
Figure 15. Control Panel Faceplate Screws - Step 12.
Figure 16. Engine Start/Engine Stop Switch Red Jumper Wires - Step 12.
Figure 18. Engine Start/Engine Stop Switch Orange Wire - Step 13.
Figure 20. Interconnect Terminal Strip - Step 14.
Figure 22. Governor Controller Harness Connector Pin A2 - Step 15.
ENGINE DOES NOT CRANK - Continued
ENGINE CRANKS BUT DOES NOT START
Figure 2. Air Filter Restriction Indicator - Step 2.
Figure 3. Governor Actuator Harness - Step 3.
Figure 4. Engine Timing Sensor Harness Connector - Step 4.
Figure 5. Fuel System Components - Step 5.
Figure 6. Flatrack Fuel Lines - Step 6.
Figure 7. Engine Injection Pump Banjo-Fitting - Step 7.
Figure 9. Engine Injector Pump Banjo-Fitting - Step 8.
Figure 10. Fuel/Water Separator Supply Line - Step 8.
ENGINE CRANKS BUT DOES NOT START - Continued
EXCESSIVELY LONG CRANK TIMES
EXCESSIVELY LONG CRANK TIMES - Continued
Table 1. Battery State Of Charge Voltage Table.
Figure 2. Air Filter Restriction Indicator - Step 4.
Figure 4. Fuel System Components - Step 6.
Figure 5. Engine Injection Pump Banjo Fitting - Step 7.
Figure 7. Engine Injection Pump Banjo Fitting - Step 8.
Figure 8. Fuel/Water Separator Supply Line - Step 8.
EXCESSIVELY LONG CRANK TIMES - Continued
ENGINE STALLS
Figure 1. Fuel Tank - Step 1.
Figure 3. Water Pump Outlet Gauge - Step 3.
Figure 4. Engine Temp Gauge - Step 4.
Figure 6. Fuel System Components - Step 6.
Figure 7. Engine Injection Pump Banjo-Fitting - Step 7.
Figure 9. Engine Injection Pump Banjo-Fitting - Step 8.
Figure 10. Fuel/Water Separator Supply Line - Step 8.
ENGINE STALLS - Continued
ENGINE SURGES
Figure 2. Air Filter And Air Cleaner - Step 2.
Figure 3. Fuel Lines - Step 3.
Figure 4. Fuel System Components - Step 4.
Figure 5. Engine Injection Pump Banjo-Fitting - Step 5.
Figure 7. Engine Injection Pump Banjo-Fitting - Step 6.
Figure 8. Fuel/Water Separator Supply Line - Step 6.
ENGINE SURGES - Continued
ENGINE MISFIRES
Figure 1. Air Vent Cock - Step 2.
Figure 3. Air Vent Cock (Close) - Step 2.
Figure 5. Engine Injection Pump Banjo-Fitting - Step 4.
Figure 6. Engine Start/Engine Stop Switch - Step 4.
Figure 7. Engine Injection Pump Banjo-Fitting - Step 5.
Figure 8. Fuel/Water Separator Supply Line - Step 5.
ENGINE MISFIRES - Continued
ENGINE WILL NOT INCREASE RPM
ENGINE WILL NOT INCREASE RPM - Continued
Figure 2. Control Panel Faceplate Screws - Step 2.
Figure 4. Governor Controller Harness Connector Pin E1 - Step 2.
Figure 6. Governor Actuator Harness - Step 4.
Figure 7. RPM Switch Red/White Wire - Step 5.
Figure 9. Interconnect Terminal Strip - Step 6.
ENGINE WILL NOT INCREASE RPM - Continued
EXCESSIVE ENGINE VIBRATION
Figure 2. Alternator Belt And Water Pump Pulley - Step 2.
Figure 3. Engine Mounts - Step 3.
Figure 4. Cooling Fan - Step 4.
EXCESSIVE ENGINE NOISE
Figure 1. Air Cleaner And Air Filter - Step 2.
Figure 2. Alternator Belt - Step 3.
Figure 3. Engine Inlet Assembly Manifold - Step 4.
Figure 5. Cooling Fan - Step 6.
ENGINE OVERHEATS
Figure 1. Alternator Belt - Step 2.
ENGINE OVERHEATS - Continued
Figure 2. Engine Temperature Gauge - Step 7.
Figure 3. Engine Temperature Gauge - Step 8.
ENGINE DOES NOT REACH NORMAL OPERATING TEMPERATURE
Figure 1. Engine Temperature Gauge - Step 2.
EXCESSIVE ENGINE OIL CONSUMPTION
EXCESSIVE ENGINE OIL CONSUMPTION - Continued
EXCESSIVE FUEL CONSUMPTION
Figure 2. Air Filter - Step 2.
Figure 3. Fuel System Components - Step 3.
Figure 4. Fuel Lines - Step 4.
EXCESSIVE FUEL CONSUMPTION - Continued
ENGINE KNOCK
ENGINE KNOCK - Continued
BLACK/BLUE EXHAUST SMOKE
Figure 2. Air Filter - Step 2.
BLACK/BLUE EXHAUST SMOKE - Continued
WHITE EXHAUST SMOKE
WHITE EXHAUST SMOKE - Continued
WHITE EXHAUST SMOKE - Continued
WATER PUMP DOES NOT OPERATE
Figure 2. Flex Element - Step 2.
WATER PRESSURE ERRATIC
WATER PRESSURE ERRATIC - Continued
EXCESSIVE WATER PUMP NOISE
Figure 2. Water Pump Isolation Mounts - Step 2.
Figure 4. Flex Element - Step 4.
WORK LIGHTS DO NOT ILLUMINATE
Figure 2. Engine Off/Battery Drain Indicator - Step 2.
Figure 3. Work Light Harness Connector Pin 1 - Step 3.
Figure 4. Work Light Harness Connector Pin 2 - Step 4.
Figure 5. Control Panel Faceplate Screws - Step 5.
Figure 7. Light Switch - Step 6.
Figure 9. Lights Switch - Step 7.
WATER DISTRIBUTOR DOES NOT OPERATE REMOTELY
WATER DISTRIBUTOR DOES NOT OPERATE REMOTELY - Continued
NO POWER TO CONTROL PANEL
Figure 2. Battery Voltage Gauge - Step 2.
Figure 3. Batteries And Battery Terminals - Step 3.
Figure 5. Battery Terminals - Step 5.
Table 1. Battery State Of Charge Voltage Table - Step 5
Figure 6. Control Panel Faceplate Screws - Step 6.
Figure 8. Emergency Stop Switch, Terminal 2- Step 7.
Figure 9. Negative Terminal Strip - Step 8.
Figure 10. Negative Battery Terminal - Step 8.
Figure 11. 15-amp Circuit Breaker Terminal 1 - Step 9.
NO POWER TO CONTROL PANEL - Continued
BATTERY VOLTAGE GAUGE DOES NOT OPERATE OR READS HIGH
Figure 1. Engine Off/Battery Drain Indicator - Step 1.
Figure 2. Control Panel Faceplate Screws - Step 2.
Figure 4. Gauge Harness Connector - Step 3.
Figure 5. Negative Terminal Strip - Step 3.
BATTERY VOLTAGE GAUGE DOES NOT OPERATE OR READS HIGH - Continued
BATTERY VOLTAGE GAUGE READS LOW
Figure 1. Battery Voltage Gauge - Step 2.
Figure 2. Battery Terminals - Step 3.
Figure 3. Control Panel Faceplate Screws - Step 4.
Figure 4. Gauge Harness Connector - Step 4.
Figure 5. Positive Terminal Strip - Step 4.
Figure 6. Gauge Harness Connector - Step 5.
Figure 8. Red Wire At Alternator - Step 6.
Figure 9. Positive Battery Terminal - Step 6.
BATTERY VOLTAGE GAUGE READS LOW - Continued
BATTERY VOLTAGE GAUGE READS HIGH
Figure 1. Battery Terminals - Step 1.
Figure 2. Battery Terminals - Step 2.
Figure 3. Battery Voltage Gauge - Step 3.
ENGINE OFF/BATTERY DRAIN INDICATOR DOES NOT ILLUMINATE
Figure 1. Control Panel Faceplate Screws - Step 2.
Figure 2. Positive Terminal Strip - Step 2.
Figure 3. Engine Off/Battery Drain Indicator - Step 3.
Figure 5. Engine Off/Battery Drain Indicator - Step 4.
Figure 7. Engine Off/Battery Drain Indicator - Step 5.
ENGINE OFF/BATTERY DRAIN INDICATOR STAYS ILLUMINATED
Figure 1. Control Panel Faceplate Screws - Step 2.
Figure 2. Interconnect Terminal Strip - Step 2.
Figure 3. Interconnect Terminal Strip - Step 3.
Figure 5. Engine Off/Battery Drain Indicator - Step 5.
ENGINE OIL PRESSURE GAUGE READS LOW
Figure 1. Engine Oil Pressure Switch - Step 3.
Figure 2. Engine Oil Pressure Gauge - Step 5.
ENGINE OIL PRESSURE GAUGE READS LOW OR READS HIGH
Figure 2. Engine Oil Pressure Gauge - Step 3.
Figure 3. Engine Oil Pressure Gauge - Step 3.
ENGINE OIL PRESSURE GAUGE INOPERATIVE OR READS HIGH
Figure 2. Control Panel Faceplate Screws - Step 2.
Figure 3. Gauge Harness Connector - Step 2.
Figure 5. Gauge Harness Connector - Step 3.
Figure 6. Negative Terminal Strip - Step 3.
Figure 7. Gauge Harness Connector - Step 4.
Figure 9. Gauge Harness Connector - Step 5.
Figure 11. Engine Oil Pressure Gauge - Step 6.
ENGINE TEMPERATURE GAUGE INOPERATIVE OR READS HIGH
Figure 2. Control Panel Faceplate Screws - Step 2.
Figure 3. Gauge Harness Connector - Step 2.
Figure 5. Gauge Harness Connector - Step 3.
Figure 6. Negative Terminal Strip - Step 3.
Figure 7. Gauge Harness Connector - Step 4.
Figure 9. Gauge Harness Connector - Step 5.
Figure 11. Engine Temperature Gauge - Step 6.
MAIN CONTROL PANEL TACHOMETER DOES NOT OPERATE
Figure 2. Control Panel Faceplate Screws - Step 2.
Figure 4. Tachometer Red Wire - Step 3.
Figure 5. Tachometer Black Wire - Step 4.
Figure 6. Negative Terminal Strip - Step 4.
Figure 8. Tachometer Grey Wire - Step 5.
Figure 10. Tachometer Grey Wire - Step 6.
Figure 12. Tachometer - Step 7.
WATER PUMP INLET GAUGE DOES NOT OPERATE
Figure 2. Water Pump Inlet Gauge And Hose - Step 2.
Figure 3. Water Pump Inlet Gauge - Step 3.
WATER PUMP OUTLET GAUGE DOES NOT OPERATE
Figure 2. Water Pump Outlet Gauge And Hose - Step 2.
Figure 3. Water Pump Outlet Gauge - Step 3.
MAIN CONTROL PANEL ENGINE SPEED RESUME/IDLE SWITCH DOES NOT OPERATE
Figure 2. Engine Resume/Idle Switch - Step 1.
Figure 3. Engine Resume/Idle Switch - Step 2.
Figure 5. Engine Resume/Idle Switch - Step 3.
Figure 7. Engine Resume/Idle Switch - Step 4.
Figure 8. Engine Start/Engine Stop Switch - Step 4.
Figure 9. Engine Resume/Idle Switch - Step 5.
Figure 11. Engine Resume/Idle Switch - Step 6.
Figure 12. Interconnect Terminal Strip - Step 6.
ENGINE SPEED RPM SWITCH DOES NOT OPERATE
Figure 2. Engine Speed RPM Switch - Step 1.
Figure 3. Engine Speed RPM Switch - Step 2.
Figure 5. Engine Speed RPM Switch - Step 3.
Figure 7. Engine Speed RPM Switch - Step 4.
Figure 9. Engine Speed RPM Switch - Step 5.
Figure 11. Engine Speed RPM Switch - Step 6.
ENGINE SPEED RPM SWITCH DOES NOT OPERATE - Continued
MAIN CONTROL PANEL ENGINE SPEED SET SWITCH DOES NOT OPERATE
Figure 2. Engine Speed Set Switch - Step 1.
Figure 3. Engine Speed Set Switch - Step 2.
Figure 6. Engine Speed RPM Switch - Step 3.
Figure 7. Engine Speed Set Switch - Step 4.
MAIN CONTROL PANEL ENGINE SPEED SET SWITCH DOES NOT OPERATE - Continued
LEFT WATER SPRINKLERS SWITCH DOES NOT OPERATE
Figure 1. Left Water Sprinklers Switch - Step 2.
Figure 3. Control Panel Faceplate Screws - Step 3.
Figure 4. Negative Terminal Strip - Step 3.
Figure 6. Control Panel Faceplate Screws - Step 4.
Figure 7. Left Water Sprinkler Switch - Step 4.
Figure 8. Left Water Sprinklers Switch - Step 5.
LEFT WATER SPRINKLERS SWITCH DOES NOT OPERATE - Continued
RIGHT WATER SPRINKLERS SWITCH DOES NOT OPERATE
Figure 1. Right Water Sprinklers Switch - Step 2.
Figure 3. Control Panel Faceplate Screws - Step 3.
Figure 4. Negative Terminal Strip - Step 3.
Figure 6. Control Panel Faceplate Screws - Step 4.
Figure 7. Right Water Sprinkler Switch - Step 4.
Figure 8. Right Water Sprinklers Switch - Step 5.
RIGHT WATER SPRINKLERS SWITCH DOES NOT OPERATE - Continued
WATER LEVEL HIGH INDICATOR DOES NOT ILLUMINATE
Figure 2. WATER LEVEL HIGH Indicator - Step 1.
Figure 4. Water Level High Indicator - Step 2.
Figure 6. Control Panel Faceplate Screws - Step 4.
Figure 7. Water Level Indicator And Magnet - Step 4.
Figure 9. Positive Terminal Strip - Step 5.
Figure 11. Water Level High Indicator - Step 6.
Figure 13. Water Level High Indicator - Step 7.
Figure 15. Water Level Indicator And Magnet - Step 8.
WATER LEVEL HIGH INDICATOR DOES NOT ILLUMINATE - Continued
MAIN CONTROL PANEL WATER LEVEL LOW INDICATOR DOES NOT ILLUMINATE
Figure 2. Water Level Low Indicator - Step 1.
Figure 4. Water Level High Indicator - Step 2.
Figure 6. Control Panel Faceplate Screws - Step 4.
Figure 7. Water Level Indicator And Magnet - Step 4.
Figure 9. Positive Terminal Strip - Step 5.
Figure 11. Water Level Low Indicator - Step 6.
Figure 13. Water Level Low Indicator - Step 7.
Figure 15. Water Level Indicator And Magnet - Step 8.
MAIN CONTROL PANEL WATER LEVEL LOW INDICATOR DOES NOT ILLUMINATE - Continued
MAIN CONTROL PANEL WATER LEVEL HIGH INDICATOR STAYS ILLUMINATED
Figure 1. High Tank Level Switch Harness Connector - Step 1.
Figure 2. Control Panel Faceplate Screws - Step 2.
Figure 4. Interconnect Terminal Strip - Step 2.
Figure 5. Water Level High Indicator - Step 3.
MAIN CONTROL PANEL WATER LEVEL LOW INDICATOR STAYS ILLUMINATED
Figure 1. Low Tank Level Switch Harness Connector - Step 1.
Figure 2. Control Panel Faceplate Screws - Step 2.
Figure 4. Interconnect Terminal Strip - Step 2.
Figure 5. Water Level Low Indicator - Step 3.
MANUAL WATER TURRET DOES NOT OPERATE
Figure 2. Water Pump Outlet Gauge - Step 3.
MANUAL WATER TURRET PRESSURE LOW
Figure 2. Valve V6 - Step 2.
Figure 3. Valve V5 - Step 3.
Figure 4. Water Pump Outlet Gauge - Step 3.
GRAVITY BAR WELDMENT DOES NOT OPERATE
Figure 2. Closure Cap C2 - Step 2.
Figure 3. Water Tank Sump - Test 3.
GRAVITY BAR WELDMENT STREAM LOW
Figure 2. Closure Cap C2 - Step 2.
Figure 3. Water Tank Sump - Test 3.
WATER SPRINKLERS DO NOT OPERATE
Figure 1. Water Sprinkler Head - Step 2.
Figure 2. Air Hoses - Step 3.
Figure 3. Left And Right Solenoid Valves - Step 4.
Figure 4. Air Hoses - Step 7.
WATER SPRINKLER HEAD PRESSURE LOW
Figure 1. Air Hoses - Step 3.
Figure 2. Water Sprinkler Head - Step 4.
WATER SPRINKLER HEAD PRESSURE LOW - Continued
WATER HOSE INOPERATIVE
Figure 2. Water Hose Nozzle - Step 3.
WATER HOSE INOPERATIVE - Continued
WATER HOSE PRESSURE LOW
Figure 2. Water Hose Nozzle - Step 2.
CAB CONTROL BOX ENGINE OFF/BATTERY DRAIN INDICATOR INOPERATIVE
CAB CONTROL BOX ENGINE OFF/BATTERY DRAIN INDICATOR INOPERATIVE - Continued
Figure 3. UPIK Air And Electrical Connections - Step 3.
Figure 5. Cab Control Box Engine Off/Battery Drain Indicator - Step 4.
Figure 7. UPIK Harness Connector Pin J - Step 5.
Figure 8. Cab Control Box Engine Off/Battery Drain Indicator - Step 6.
Figure 10. UPIK Harness Connector Pin I - Step 7.
Figure 11. Cab Control Box Engine Off/Battery Drain Indicator - Step 8.
CAB CONTROL BOX LIGHTS SWITCH DOES NOT OPERATE
Figure 1. Cab Control Box - Step 2.
Figure 3. Cab Control Box Screws - Step 3.
Figure 5. Cab Control Box Lights Switch - Step 4.
Figure 6. UPIK Electrical Connection - Step 5.
Figure 8. Cab Control Box Lights Switch - Step 6.
CAB CONTROL BOX TACHOMETER DOES NOT OPERATE
Figure 2. Cab Control Box - Step 2.
Figure 4. Cab Control Box Screws - Step 3.
Figure 6. Cab Control Box Tachometer - Step 4.
Figure 7. Cab Control Box Tachometer - Step 5.
Figure 9. UPIK Harness Connector Pin V - Step 6.
Figure 10. UPIK Electrical Connection - Step 7.
Figure 12. Tachometer - Step 8.
CAB CONTROL BOX ENGINE SPEED RESUME/IDLE SWITCH DOES NOT OPERATE
Figure 1. Cab Control Box - Step 2.
Figure 3. Cab Control Box Screws - Step 3.
Figure 5. Cab Control Box Engine Speed Resume/Idle Switch - Step 4.
Figure 6. Cab Control Box Engine Speed Resume/Idle Switch - Step 5.
Figure 7. UPIK Electrical Connection - Step 6.
Figure 9. UPIK Electrical Connection - Step 7.
Figure 10. UPIK Harness Connector Pin B - Step 7.
CAB CONTROL BOX ENGINE SPEED RESUME/IDLE SWITCH DOES NOT OPERATE - Continued
CAB CONTROL BOX ENGINE SPEED RPM SWITCH DOES NOT OPERATE
Figure 1. Cab Control Box - Step 2.
Figure 3. Cab Control Box Screws - Step 3.
Figure 5. Cab Control Box Engine Speed RPM Switch - Step 4.
Figure 6. Cab Control Box Engine Speed RPM Switch - Step 5.
Figure 7. UPIK Electrical Connection - Step 6.
Figure 9. UPIK Electrical Connection - Step 7.
Figure 10. UPIK Harness Connector Pin D - Step 7.
CAB CONTROL BOX ENGINE SPEED RPM SWITCH DOES NOT OPERATE - Continued
CAB CONTROL BOX ENGINE SPEED SET SWITCH DOES NOT OPERATE
Figure 1. Cab Control Box - Step 2.
Figure 3. Cab Control Box Screws - Step 3.
Figure 5. Cab Control Box Engine Speed Set Switch - Step 4.
Figure 6. UPIK Electrical Connection - Step 5.
Figure 8. Cab Control Box Engine Speed Set Switch - Step 6.
CAB CONTROL BOX WATER SPRINKLER SWITCH (LEFT) INOPERATIVE
Figure 1. Cab Control Box - Step 2.
Figure 3. Cab Control Box Screws - Step 3.
Figure 5. Cab Control Box Left Water Sprinkler Switch - Step 4.
Figure 6. UPIK Electrical Connection - Step 5.
Figure 7. UPIK Harness Connector Pin M - Step 5.
CAB CONTROL BOX WATER SPRINKLER SWITCH (LEFT) INOPERATIVE - Continued
CAB CONTROL BOX WATER SPRINKLER SWITCH (RIGHT) INOPERATIVE
Figure 1. Cab Control Box - Step 2.
Figure 3. Cab Control Box Screws - Step 3.
Figure 5. Cab Control Box Right Water Sprinkler Switch - Step 4.
Figure 6. UPIK Electrical Connection - Step 5.
Figure 8. Right Water Sprinkler Switch - Step 6.
CAB CONTROL BOX WATER LEVEL HIGH INDICATOR DOES NOT ILLUMINATE
Figure 2. Water Level High Indicator - Step 1.
Figure 4. UPIK Air And Electrical Connections - Step 2.
Figure 6. Cab Control Box Water Level High Indicator - Step 3.
Figure 8. UPIK Harness Connector Pin K - Step 4.
Figure 9. Cab Control Box Water Level High Indicator - Step 5.
Figure 10. Cab Control Box Water Level High Indicator - Step 6.
Figure 12. Cab Control Box Water Level High Indicator - Step 7.
CAB CONTROL BOX WATER LEVEL LOW INDICATOR DOES NOT ILLUMINATE
Figure 2. Water Level Low Indicator - Step 1.
Figure 4. UPIK Air And Electrical Connections - Step 2.
Figure 6. Cab Control Box Water Level Low Indicator - Step 3.
Figure 8. UPIK Harness Connector Pin L - Step 4.
Figure 9. Cab Control Box Water Level Low Indicator - Step 5.
Figure 11. Water Level Indicator And Magnet - Step 6.
CAB CONTROL BOX ENGINE START/STOP SWITCH DOES NOT OPERATE
Figure 1. Cab Control Box - Step 2.
Figure 3. Cab Control Box Screws - Step 3.
Figure 5. Cab Control Box Engine Start/Stop Switch - Step 4.
Figure 6. Cab Control Box Engine Start/Stop Switch - Step 5.
Figure 7. UPIK Electrical Connection - Step 6.
Figure 9. UPIK Electrical Connection - Step 7.
Figure 10. UPIK Harness Connector Pin F - Step 7.
CAB CONTROL BOX ENGINE START/STOP SWITCH DOES NOT OPERATE - Continued
CHAPTER 3. PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS)
INTRODUCTION - FIELD LEVEL PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - Continued
Table 1. FIELD LEVEL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS)
Table 1. FIELD LEVEL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - Continued
Figure 2. Engine.
Figure 3. Belt.
Figure 4. Cooling System.
Figure 5. Water Tank and Accessories.
Figure 6. Hook Bar.
Figure 7. Water Tank Mount Screws.
Figure 8. Air Lubricator.
Figure 9. Oil Filter.
Figure 10. Air Filter.
Figure 11. Water Pump.
Figure 12. Starter.
Figure 13. Air Filter.
CHAPTER 4. MAINTENANCE INSTRUCTIONS
COOLANT RESERVOIR REPLACEMENT
Figure 2. Coolant Reservoir Removal.
Figure 4. Coolant Reservoir Installation.
Figure 6. Coolant Reservoir Installation.
WATER PUMP AND HOUSING REPLACEMENT
Figure 2. Water Pump and Housing Removal.
Figure 3. Water Pump and Housing Removal.
Figure 4. Water Pump and Housing Removal.
Figure 5. Water Pump and Housing Installation.
Figure 6. Water Pump and Housing Installation.
Figure 7. Water Pump and Housing Installation.
COOLING FAN REPLACEMENT
Figure 2. Cooling Fan Removal.
Figure 4. Cooling Fan Installation.
UPPER COOLING SYSTEM HOSE REPLACEMENT
Figure 2. Upper Cooling System Hose Installation.
COOLING SYSTEM SERVICING AND TESTING
Figure 1. Cooling System Flushing.
Figure 2. Cooling System Flushing.
Figure 4. Cooling System Flushing.
Figure 6. Cooling System Flushing.
Figure 8. Cooling System Flushing.
Figure 9. Cooling System Flushing.
Figure 11. Cooling System Flushing.
Figure 12. Cooling System Flushing.
Figure 14. Cooling System Flushing.
Figure 16. Cooling System Flushing.
Figure 17. Cooling System Flushing.
Figure 19. Cooling System Flushing.
Figure 21. Cooling System Pressure Testing.
Figure 23. Cooling System Pressure Testing.
Figure 24. Cooling System Pressure Testing.
RADIATOR DRAIN/FILL
Figure 2. Radiator Drain Cock.
Figure 3. Radiator Fill Point.
Figure 5. Radiator Cap Access Door.
RADIATOR AND BRACKET REPLACEMENT
Figure 2. Radiator and Bracket Removal.
Figure 4. Radiator and Bracket Removal.
Figure 6. Radiator and Bracket Removal.
Figure 8. Radiator and Bracket Removal.
Figure 10. Radiator and Bracket Installation.
Figure 12. Radiator and Bracket Installation.
Figure 13. Radiator and Bracket Installation.
Figure 15. Radiator and Bracket Installation.
LOWER RADIATOR HOSE REPLACEMENT
Figure 2. Lower Radiator Hose Installation.
15-AMP CIRCUIT BREAKER REPLACEMENT
Figure 2. 15-amp Circuit Breaker Removal.
Figure 4. 15-amp Circuit Breaker Removal.
Figure 6. 15-amp Circuit Breaker Installation.
Figure 7. 15-amp Circuit Breaker Installation.
ALTERNATOR BELT ADJUSTMENT
Figure 2. Alternator Belt Adjustment.
ALTERNATOR BELT ADJUSTMENT - Continued
ALTERNATOR BELT REPLACEMENT
Figure 2. Alternator Belt Removed.
Figure 4. Alternator Belt Removed.
Figure 6. Alternator Belt Installation.
Figure 8. Alternator Belt Installation.
ALTERNATOR AND BRACKET REPLACEMENT
Figure 2. Alternator Removal.
Figure 4. Alternator Removal.
Figure 6. Alternator Installation.
Figure 8. Alternator Installation.
BATTERIES SERVICING AND TESTING
Figure 1. Battery Testing.
Figure 2. Clean Battery Cables.
Figure 4. Battery Service.
BATTERY BOX REPLACEMENT
Figure 1. Battery Box Removal.
Figure 2. Battery Box Installation.
BATTERY BOX WIRING REPLACEMENT
Figure 1. Battery Box Wiring Removal.
Figure 3. Battery Box Wiring Removal.
Figure 5. Battery Box Wiring Removal.
Figure 7. Battery Box Wiring Removal.
Figure 8. Battery Box Wiring Removal.
Figure 10. Battery Box Wiring Installation.
Figure 11. Battery Box Wiring Installation.
Figure 13. Battery Box Wiring Installation.
Figure 15. Battery Box Wiring Installation.
BATTERY BOX WIRING REPLACEMENT - Continued
BATTERY DISCONNECT/CONNECTION
Figure 1. Disconnect Batteries.
Figure 3. Disconnect Batteries.
Figure 4. Connect Batteries.
Figure 5. Connect Batteries.
BATTERY DISCONNECT/CONNECTION - Continued
BATTERY REPLACEMENT
Figure 1. Battery Removal.
BATTERY REPLACEMENT - Continued
MAIN CONTROL PANEL BATTERY VOLTAGE GAUGE REPLACEMENT
Figure 2. Main Control Panel Battery Voltage Gauge Removal.
Figure 4. Main Control Panel Battery Voltage Gauge Installation.
Figure 5. Main Control Panel Battery Voltage Gauge Installation.
MAIN CONTROL PANEL EMERGENCY STOP PUSHBUTTON REPLACEMENT
Figure 2. Main Control Panel Emergency Stop Pushbutton Removal.
Figure 4. Main Control Panel Emergency Stop Pushbutton Installation.
Figure 6. Main Control Panel Emergency Stop Pushbutton Installation.
CONTROL PANEL LIGHT SWITCH REPLACEMENT
Figure 2. Control Panel Light Switch Removal.
Figure 4. Control Panel Light Switch Removal.
Figure 6. Control Panel Light Switch Installation.
Figure 8. Control Panel Light Switch Installation.
MAIN CONTROL PANEL OIL PRESSURE GAUGE REPLACEMENT
Figure 2. Main Control Panel Oil Pressure Gauge Removal.
Figure 4. Main Control Panel Oil Pressure Gauge Installation.
Figure 5. Main Control Panel Oil Pressure Gauge Installation.
MAIN CONTROL PANEL ENGINE START/STOP SWITCH REPLACEMENT
Figure 2. Main Control Panel Engine Start/Stop Switch Removal.
Figure 4. Main Control Panel Engine Start/Stop Switch Removal.
Figure 6. Main Control Panel Engine Start/Stop Switch Installation.
Figure 8. Main Control Panel Engine Start/Stop Switch Installation.
GOVERNOR CONTROL MODULE REPLACEMENT
Figure 2. Governor Control Module Removal.
Figure 4. Governor Control Module Installation.
MAIN CONTROL PANEL ENGINE OFF/BATTERY DRAIN INDICATOR REPLACEMENT
Figure 2. Main Control Panel Engine Off/Battery Drain Indicator Removal.
Figure 4. Main Control Panel Engine Off/Battery Drain Indicator Installation.
Figure 5. Main Control Panel Engine Off/Battery Drain Indicator Installation.
MAIN CONTROL PANEL ENGINE SPEED RESUME/IDLE SWITCH REPLACEMENT
Figure 2. Main Control Panel Engine Speed Resume/Idle Switch Removal.
Figure 4. Main Control Panel Engine Speed Resume/Idle Switch Removal.
Figure 6. Main Control Panel Engine Speed Resume/Idle Switch Installation.
Figure 7. Main Control Panel Engine Speed Resume/Idle Switch Installation.
MAIN CONTROL PANEL ENGINE SPEED RPM SWITCH REPLACEMENT
Figure 2. Main Control Panel Engine Speed RPM Switch Removal.
Figure 4. Main Control Panel Engine Speed RPM Switch Removal.
Figure 6. Main Control Panel Engine Speed RPM Switch Installation.
Figure 7. Main Control Panel Engine Speed RPM Switch Installation.
MAIN CONTROL PANEL ENGINE SPEED SET SWITCH REPLACEMENT
Figure 2. Main Control Panel Engine Speed Set Switch Removal.
Figure 4. Main Control Panel Engine Speed Set Switch Removal.
Figure 6. Main Control Panel Engine Speed Set Switch Installation.
Figure 8. Main Control Panel Engine Speed RPM Switch Installation.
MAIN CONTROL PANEL ENGINE TEMPERATURE GAUGE REPLACEMENT
Figure 2. Main Control Panel Engine Temperature Gauge Removal.
Figure 4
Figure 6. Main Control Panel Engine Temperature Gauge Installation.
ENGINE WIRE HARNESS REPLACEMENT
Figure 2. Engine Wire Harness Removal.
Figure 4. Engine Wire Harness Removal.
Figure 6. Engine Wire Harness Removal.
Figure 8. Engine Wire Harness Removal.
Figure 10. Engine Wire Harness Removal.
Figure 11. Engine Wire Harness Removal.
Figure 12. Engine Wire Harness Installation.
Figure 13. Engine Wire Harness Installation.
Figure 15. Engine Wire Harness Installation.
Figure 16. Engine Wire Harness Installation.
Figure 18. Engine Wire Harness Installation.
Figure 20. Engine Wire Harness Installation.
Figure 22. Engine Wire Harness Installation.
GENERAL WIRE HARNESS REPAIR/JUMPER WIRE FABRICATION
Figure 1. DT Style Connector Receptacle Repair.
Figure 2. DT Style Connector Plug Repair.
Figure 3. Spade Connector Repair.
Figure 5. Connector Breakdown.
Figure 7. Wire Seal With Insulation.
Figure 8. Seating Terminal to Connector.
Figure 10. Splicing.
Figure 12. Before Joint Is Soldered.
Figure 13. Joint With Solder.
Figure 15. Splice Double Joint Soldering.
Figure 17. Double Joint With Solder and Heatshrink.
Figure 18. Jumper Wire Fabrication.
MAIN CONTROL BOX REPLACEMENT
Figure 1. Engine Wire Harness Removal.
Figure 2. Alternator Wire Harness Removal.
Figure 3. UPIK Wire Harness Removal.
Figure 4. Work Light Wire Harness Removal.
Figure 5. Sprinkler Wire Harness Removal.
Figure 6. Water Level Wire Harness Removal.
Figure 8. Main Control Box Removal.
Figure 9. Main Control Box Removal.
Figure 11. Main Control Box Installation.
Figure 12. Main Control Box Installation.
Figure 14. Battery Wire Harness Installation.
Figure 15. Water Level Wire Harness Installation.
Figure 17. Work Light Wire Harness Installation.
Figure 18. UPIK Wire Harness Installation.
Figure 19. Alternator Wire Harness Installation.
Figure 20. Engine Wire Harness Installation.
MAIN CONTROL BOX REPLACEMENT - Continued
NATO SLAVE CONNECTOR REPLACEMENT
Figure 2. NATO Slave Cable Removal.
Figure 4. NATO Slave Cable Removal.
Figure 6. NATO Slave Cable Installation.
Figure 7. NATO Slave Connector Installation.
NATO SLAVE CONNECTOR REPLACEMENT - Continued
MAIN CONTROL PANEL TACHOMETER/HOURMETER REPLACEMENT
Figure 2. Main Control Panel Tachometer/Hourmeter Removal.
Figure 4. Main Control Panel Tachometer/Hourmeter Removal.
Figure 6. Main Control Panel Tachometer/Hourmeter Installation.
Figure 7. Main Control Panel Tachometer/Hourmeter Installation.
Figure 9. Main Control Panel Tachometer/Hourmeter Installation.
Figure 10. Main Control Panel Tachometer/Hourmeter Installation.
MAIN CONTROL PANEL WATER LEVEL HIGH INDICATOR REPLACEMENT
Figure 2. Main Control Panel Water Level High Indicator Removal.
Figure 4. Main Control Panel Water Level High Indicator Installation.
Figure 6. Main Control Panel Water Level High Indicator Installation.
MAIN CONTROL PANEL WATER LEVEL LOW INDICATOR REPLACEMENT
Figure 2. Main Control Panel Water Level Low Indicator Removal.
Figure 4. Main Control Panel Water Level Low Indicator Installation.
Figure 6. Main Control Panel Water Level Low Indicator Installation.
MAIN CONTROL PANEL WATER SPRINKLER SWITCH REPLACEMENT
Figure 2. Main Control Panel Water Sprinkler Switch Removal.
Figure 4. Main Control Panel Water Sprinkler Switch Removal.
Figure 5. Main Control Panel Water Sprinkler Switch Installation.
Figure 7. Main Control Panel Water Sprinkler Switch Installation.
Figure 8. Main Control Panel Water Sprinkler Switch Installation.
WORK LIGHT REPLACEMENT
Figure 1. Work Light Removal.
Figure 2. Work Light Removal.
Figure 3. Work Light Installation.
WORK LIGHT REPLACEMENT - Continued
WORK LIGHT WIRE HARNESS REPLACEMENT
Figure 2. Work Light Wire Harness Removal.
Figure 4. Work Light Wire Harness Removal.
Figure 6. Work Light Wire Harness Removal.
Figure 8. Work Light Wire Harness Installation.
Figure 10. Work Light Wire Harness Installation.
Figure 12. Work Light Wire Harness Installation.
UPIK WIRE HARNESS REPLACEMENT
Figure 2. UPIK Wire Harness Removal.
UPIK WIRE HARNESS REPLACEMENT - Continued
Figure 4. UPIK Wire Harness Removal.
Figure 5. UPIK Wire Harness Removal.
Figure 6. UPIK Wire Harness Installation.
Figure 7. UPIK Wire Harness Installation.
Figure 8. UPIK Wire Harness Installation.
Figure 9. UPIK Wire Harness Installation.
Figure 10. UPIK Wire Harness Installation.
AIR HOSE INTAKE REPLACEMENT
Figure 2. Air Hose Intake Installation.
CRANKSHAFT PULLEY REPLACEMENT
Figure 2. Crankshaft Pulley Removal.
Figure 4. Crankshaft Pulley Installation.
ENGINE CRANKSHAFT FRONT SEAL REPLACEMENT
Figure 2. Engine Crankshaft Front Seal Installation.
ENGINE FLYWHEEL REPLACEMENT
Figure 1. Engine Flywheel Removal.
ENGINE FLYWHEEL REPLACEMENT - Continued
INJECTION PUMP GEAR COVER PLATE REPLACEMENT
Figure 2. Injection Pump Gear Cover Plate Removal.
Figure 4. Injection Pump Gear Cover Plate.
Figure 6. Injection Pump Gear Cover Plate Installation.
Figure 7. Injection Pump Gear Cover Plate Installation.
Figure 9. Injection Pump Gear Cover Plate Installation.
ENGINE GEAR ASSEMBLY CASE RELIEF VALVE REPLACEMENT
Figure 1. Engine Gear Assembly Case Relief Valve Removal.
Figure 2. Engine Gear Assembly Case Relief Valve Installation.
ENGINE COOLANT TEMPERATURE SENDING UNIT REPLACEMENT
Figure 2. Engine Coolant Temperature Sending Unit Installation.
ENGINE COOLANT TEMPERATURE SENDING UNIT REPLACEMENT - Continued
ENGINE EMERGENCY TEMPERATURE SENDING UNIT REPLACEMENT
Figure 2. Engine Emergency Temperature Sending Unit Installation.
ENGINE INJECTION PUMP REPLACEMENT
Figure 1. Injection Pump Removal.
Figure 3. Injection Pump Removal.
Figure 4. Injection Pump Removal.
Figure 6. Injection Pump Removal.
Figure 7. Injection Pump Removal.
Figure 9. Injection Pump Removal.
Figure 10. Injection Pump Removal.
ENGINE NOZZLE TUBES REPLACEMENT
Figure 1. Engine Nozzle Tubes Removal.
Figure 3. Engine Nozzle Tubes Removal.
Figure 4. Engine Nozzle Tubes Installation.
Figure 5. Engine Nozzle Tubes Installation.
Figure 7. Engine Nozzle Tubes Installation.
ENGINE INLET ASSEMBLY MANIFOLD REPLACEMENT
Figure 2. Inlet Assembly Manifold Removal.
Figure 4. Inlet Assembly Manifold Installation.
Figure 6. Inlet Assembly Manifold Installation.
ENGINE NOZZLE ASSEMBLY HOLDER (INJECTION NOZZLE) REPLACEMENT
Figure 1. Injection Nozzle Assembly Removal.
Figure 2. Injection Nozzle Assembly Removal.
Figure 4. Injection Nozzle Assembly Removal.
Figure 6. Injection Nozzle Assembly Installation.
Figure 8. Injection Nozzle Assembly Installation.
OIL PAN REPLACEMENT
OIL PAN REPLACEMENT - Continued
Figure 2. Oil Pan Sealant Application.
Figure 4. Oil Pan Installation.
ENGINE OIL PRESSURE TESTING
Figure 1. Engine Oil Pressure Testing.
Figure 3. Engine Oil Pressure Testing.
Figure 4. Engine Oil Pressure Testing.
Figure 6. Engine Oil Pressure Testing.
ENGINE OIL FILTER REPLACEMENT
Figure 1. Engine Oil Filter Removal.
Figure 3. Engine Oil Filter Installation.
ENGINE OIL SERVICE
Figure 1. Engine Oil Service.
Figure 3. Engine Oil Service.
Figure 5. Engine Oil Service.
Figure 6. Engine Oil Service.
ENGINE OIL SERVICE - Continued
ENGINE OIL COOLER AND HOSE REPLACEMENT
Figure 2. Engine Oil Cooler and Hose Removal.
Figure 4. Engine Oil Cooler and Hose Removal.
Figure 6. Engine Oil Cooler and Hose Installation.
Figure 8. Engine Oil Cooler and Hose Installation.
ENGINE TIMING SENSOR AND COVER REPLACEMENT
Figure 2. Engine Timing Sensor Removal.
Figure 4. Engine Timing Sensor Installation.
ENGINE/PUMP MODULE REPLACEMENT
Figure 1. Engine/Pump Module Removal.
Figure 3. Engine/Pump Module Removal.
Figure 5. Engine/Pump Module Removal.
Figure 6. Engine/Pump Module Installation.
Figure 7. Engine/Pump Module Installation.
Figure 9. Engine/Pump Module Installation.
Figure 10. Engine/Pump Module Installation.
ENGINE MODULE REPLACEMENT
Figure 1. Engine Module Removal.
Figure 2. Engine Module Removal.
Figure 3. Engine Module Removal.
Figure 5. Engine Module Removal.
Figure 7. Engine Module Removal.
Figure 9. Engine Module Removal.
Figure 10. Engine Module Removal.
Figure 12. Engine Module Removal.
Figure 13. Engine Module Removal.
Figure 15. Engine Module Removal.
Figure 16. Engine Module Removal.
Figure 18. Engine Module Installation.
Figure 20. Engine Module Installation.
Figure 21. Engine Module Installation.
Figure 23. Engine Module Installation.
Figure 25. Engine Module Installation.
Figure 27. Engine Module Installation.
Figure 28. Engine Module Installation.
Figure 29. Engine Module Installation.
Figure 31. Engine Module Installation.
Figure 32. Engine Module Installation.
Figure 34. Engine Module Installation.
Figure 35. Engine Module Installation.
EXHAUST MANIFOLD REPLACEMENT
Figure 2. Exhaust Manifold Installation.
FRONT ENGINE MOUNT BRACKET REPLACEMENT
Figure 2. Front Engine Mount Bracket Removal.
Figure 4. Front Engine Mount Bracket Removal.
Figure 6. Front Engine Mount Bracket Installation.
Figure 8. Front Engine Mount Bracket Installation.
Figure 10. Front Engine Mount Bracket Installation.
GLOW PLUG RELAY REPLACEMENT
Figure 2. Glow Plug Relay Removal.
Figure 3. Glow Plug Relay Removal.
Figure 5. Glow Plug Relay Installation.
Figure 6. Glow Plug Relay Installation.
GLOW PLUG REPLACEMENT
Figure 2. Glow Plug Installation.
GOVERNOR ACTUATOR REPLACEMENT
Figure 2. Governor Actuator Removal.
Figure 4. Governor Actuator Installation.
OIL SAMPLING VALVE REPLACEMENT
Figure 2. Oil Sampling Valve Installation.
REAR ENGINE MOUNT BRACKET AND BUSHING REPLACEMENT
Figure 1. Rear Engine Mount Bracket and Bushing Removal.
Figure 3. Rear Engine Mount Bracket and Bushing Removal.
Figure 5. Rear Engine Mount Bracket and Bushing Removal.
Figure 7. Rear Engine Mount Bracket and Bushing Removal.
Figure 9. Rear Engine Mounting Bracket and Bushing Installation.
Figure 11. Rear Engine Mounting Bracket and Bushing Installation.
Figure 13. Rear Engine Mounting Bracket and Bushing Installation.
Figure 15. Rear Engine Mounting Bracket and Bushing Installation.
REAR MAIN SEAL REPLACEMENT
Figure 1. Rear Main Seal Removal.
Figure 3. Rear Main Seal Removal.
Figure 5. Rear Main Seal Removal.
Figure 7. Rear Main Seal Installation.
Figure 8. Rear Main Seal Installation.
Figure 10. Rear Main Seal Installation.
OIL PRESSURE SENDING UNIT AND PRESSURE SWITCH REPLACEMENT
Figure 1. Sending Unit Removal.
OIL PRESSURE SENDING UNIT AND PRESSURE SWITCH REPLACEMENT - Continued
Figure 2. Sending Unit Installation.
OIL PRESSURE SENDING UNIT AND PRESSURE SWITCH REPLACEMENT - Continued
STARTER RELAY REPLACEMENT
Figure 3. Starter Relay Removal.
Figure 4. Starter Relay Installation.
Figure 6. Starter Relay Installation.
STARTER REPLACEMENT
Figure 2. Starter Removal.
Figure 4. Starter Installation.
Figure 6. Starter Installation.
THERMOSTAT AND HOUSING REPLACEMENT
Figure 2. Thermostat and Housing Removal.
Figure 4. Thermostat and Housing Removal.
Figure 6. Thermostat and Housing Removal.
Figure 8. Thermostat and Housing Installation.
Figure 9. Thermostat and Housing Installation.
Figure 11. Thermostat and Housing Installation.
THERMOSTAT AND HOUSING REPLACEMENT - Continued
VALVE COVER AND GASKET REPLACEMENT
Figure 2. Valve Cover And Gasket Removal.
Figure 3. Valve Cover And Gasket Installation.
VALVE COVER AND GASKET REPLACEMENT - Continued
ENGINE COMPARTMENT COVER REPLACEMENT
Figure 2. Engine Compartment Cover Installation.
REAR ENCLOSURE PANEL AND SIDE RAIL REPLACEMENT
Figure 2. Rear Enclosure Panel And Side Panel Removal.
Figure 4. Rear Enclosure Panel And Side Panel Removal.
Figure 6. Rear Enclosure Panel And Side Panel Removal.
Figure 8. Rear Enclosure Panel And Side Panel Installation.
Figure 10. Rear Enclosure Panel And Side Panel Installation.
Figure 12. Rear Enclosure Panel And Side Panel Installation.
Figure 14. Rear Enclosure Panel And Side Panel Installation.
REAR ENCLOSURE PANEL AND SIDE RAIL REPLACEMENT - Continued
FRONT ENCLOSURE PANEL REPLACEMENT
Figure 2. Front Enclosure Panel Removal.
Figure 4. Front Enclosure Panel Installation.
Figure 6. Front Enclosure Panel Installation.
ENGINE CYLINDER HEAD GASKET REPLACEMENT
Figure 1. Cylinder Head Gasket Removal.
Figure 2. Cylinder Head Gasket Removal.
Figure 4. Cylinder Head Gasket Removal.
Figure 6. Cylinder Head Gasket Removal.
Figure 8. Cylinder Head Gasket Removal.
Figure 10. Cylinder Head Gasket Removal.
Figure 11. Cylinder Head Gasket Removal.
Figure 13. Cylinder Head Gasket Inspection.
Figure 15. Cylinder Head Gasket Installation.
Figure 16. Cylinder Head Gasket Installation.
Figure 17. Cylinder Head Gasket Installation.
Figure 19. Cylinder Head Gasket Installation.
Figure 21. Cylinder Head Gasket Installation.
Figure 23. Cylinder Head Gasket Installation.
ENGINE CYLINDER HEAD GASKET REPLACEMENT - Continued
BELT GUARD REPLACEMENT
Figure 2. Belt Guard Removal.
Figure 4. Belt Guard Installation.
Figure 6. Belt Guard Installation.
FLEX ELEMENT REPLACEMENT
Figure 2. Flex Element Installation.
ENGINE OIL PICKUP TUBE REPLACEMENT
Figure 2. Engine Oil Pickup Tube Removal.
Figure 4. Engine Oil Pickup Tube Installation.
EXHAUST FLEX PIPE REPLACEMENT
Figure 2. Exhaust Flex Pipe Installation.
MUFFLER AND BAND CLAMP REPLACEMENT
Figure 2. Muffler and Band Clamp Removal.
Figure 4. Muffler and Band Clamp Installation.
Figure 6. Muffler and Band Clamp Installation.
HOSE HOOK WELDMENT REPLACEMENT
Figure 2. Hose Hook Weldment Installation
SPRING MARKER REPLACEMENT
Figure 2. Spring Marker Installation.
ROLLER REPAIR
ROLLER REPAIR - Continued
Figure 2. Roller Assembly.
ROLLER REPAIR - Continued
STOWAGE BOX REPAIR
Figure 2. Stowage Box Disassembly.
Figure 4. Stowage Box Disassembly.
Figure 5. Stowage Box Assembly.
Figure 7. Stowage Box Assembly.
Figure 8. Stowage Box Installation.
STORAGE BOX REPLACEMENT
Figure 2. Storage Box Installation.
WIRE TROUGH CHANNEL REPLACEMENT
Figure 2. Wire Trough Channel Installation.
DATA PLATE REPLACEMENT
Figure 2. Data Plate Installation.
3" VALVE REPLACEMENT
Figure 2. 3" Valve Installation.
5" VALVE REPLACEMENT
Figure 2. 5" Valve Installation.
GRAVITY BAR WELDMENT REPLACEMENT
Figure 2. Gravity Bar Weldment Removal.
Figure 4. Gravity Bar Weldment Installation.
Figure 6. Gravity Bar Weldment Installation.
HOSE REEL VALVE REPLACEMENT
Figure 2. Hose Reel Valve Removal.
Figure 4. Hose Reel Valve Removal.
Figure 5. Hose Reel Valve Installation.
Figure 7. Hose Reel Valve Installation.
REAR PLATFORM REPLACEMENT
Figure 2. Rear Platform Removal.
Figure 4. Rear Platform Removal.
Figure 5. Rear Platform Removal.
Figure 6. Rear Platform Installation.
Figure 8. Rear Platform Installation.
Figure 10. Rear Platform Installation.
MANUAL WATER TURRET AND PIPING REPAIR
Figure 1. Manual Water Turret Replacement.
Figure 3. Manual Water Turret Replacement.
Figure 5. Manual Water Turret Replacement.
Figure 6. Water Turret Disassembly.
MANUAL WATER TURRET AND PIPING REPAIR - Continued
Figure 7. Water Turret Disassembly.
MANUAL WATER TURRET AND PIPING REPAIR - Continued
MANUAL WATER TURRET AND PIPING REPAIR - Continued
Figure 9. Water Turret Assembly.
Figure 10. Water Turret Assembly.
Figure 11. Water Turret Assembly.
Figure 12. Water Turret Assembly.
Figure 13. Manual Water Turret Installation.
Figure 15. Manual Water Turret Installation.
Figure 17. Manual Water Turret Installation.
MANUAL WATER TURRET AND PIPING REPAIR - Continued
AIR VALVE COVER PLATE REPLACEMENT
Figure 2. Air Valve Cover Plate Installation.
REAR PLATFORM SCREEN REPLACEMENT
Figure 2. Rear Platform Screen Installation.
FLUSHER NOZZLE AND AIR ACTUATOR REPLACEMENT
Figure 2. Flusher Nozzle Installation.
Figure 4. Flusher Nozzle and Air Actuator Removal.
Figure 6. Flusher Nozzle Removal.
Figure 7. Flusher Nozzle and Air Actuator Installation.
Figure 9. Flusher Nozzle Installation.
FLUSHER NOZZLE AND AIR ACTUATOR REPLACEMENT - Continued
FIRE EXTINGUISHER BRACKET REPLACEMENT
Figure 2. Mounting Bracket Removal.
Figure 4. Fire Extinguisher.
SOLENOID VALVE REPLACEMENT
Figure 2. Solenoid Valve Removal.
Figure 4. Solenoid Valve Removal.
Figure 6. Solenoid Valve Installation.
Figure 7. Solenoid Valve Installation.
Figure 9. Solenoid Valve Installation.
Figure 10. Solenoid Valve Installation.
AIR LINE LUBRICATOR REPLACEMENT
Figure 2. Air Line Lubricator Removal.
Figure 3. Air Line Lubricator Installation.
Figure 4. Air Line Lubricator Installation.
AIR CLEANER ASSEMBLY REPAIR
Figure 2. Air Cleaner Assembly Removal.
Figure 4. Air Cleaner Disassembly.
Figure 6. Air Cleaner Assembly.
Figure 8. Air Cleaner Assembly Installation.
Figure 10. Air Cleaner Assembly Installation.
AIR HOSE REPLACEMENT
Figure 2. Air Hose Removal.
Figure 4. Air Hose Removal.
Figure 5. Air Hose Installation.
Figure 7. Air Hose Installation.
Figure 8. Air Hose Installation.
FUEL LINE REPLACEMENT
Figure 1. Fuel Line Removal.
Figure 2. Fuel Line Removal.
Figure 3. Fuel Line Removal.
Figure 5. Fuel Line Installation.
Figure 7. Fuel Line Installation.
Figure 8. Fuel Line Installation.
FUEL PUMP ASSEMBLY REPLACEMENT
Figure 1. Fuel Pump Assembly Removal.
Figure 3. Fuel Pump Assembly Installation.
FUEL PUMP ASSEMBLY REPLACEMENT - Continued
FUEL TANK DRAIN/FILL
Figure 2. Drain Fuel Tank.
FUEL TANK DRAIN/FILL - Continued
FUEL TANK REPAIR
Figure 2. Fuel Tank Removal.
Figure 3. Fuel Tank Disassembly.
Figure 5. Fuel Tank Disassembly.
Figure 6. Fuel Tank Assembly.
Figure 7. Fuel Tank Assembly.
Figure 9. Fuel Tank Installation.
Figure 10. Fuel Tank Installation.
FUEL/WATER SEPARATOR AND FILTER HEAD REPLACEMENT
Figure 1. Fuel/Water Separator and Filter Head Removal.
Figure 2. Fuel/water Separator and Filter Head Installation.
FUEL/WATER SEPARATOR FILTER REPLACEMENT
Figure 1. Fuel/Water Separator Removal.
Figure 2. Fuel/Water Separator Installation.
FUEL/WATER SEPARATOR FILTER REPLACEMENT - Continued
WATER PUMP INLET GAUGE AND HOSE REPLACEMENT
Figure 2. Water Pump Inlet Gauge and Hose Removal.
Figure 4. Water Pump Inlet Gauge and Hose Removal.
Figure 6. Water Pump Inlet Gauge and Hose Installation.
Figure 7. Water Pump Inlet Gauge and Hose Installation.
WATER PUMP OUTLET GAUGE AND HOSE REPLACEMENT
Figure 2. Water Pump Outlet Gauge and Hose Removal.
Figure 4. Water Pump Outlet Gauge and Hose Removal.
Figure 5. Water Pump Outlet Gauge and Hose Installation.
Figure 6. Water Pump Outlet Gauge and Hose Installation.
Figure 8. Water Pump Outlet Gauge and Hose Installation.
VALVE HANDLE REPLACEMENT
Figure 2. Valve Handle Removal.
Figure 4. Valve Handle Installation.
Figure 6. Valve Handle Installation.
STRAINER ELEMENT REPLACEMENT
Figure 2. Strainer Element Installation.
STRAINER HOUSING REPLACEMENT
Figure 2. Strainer Housing Removal.
Figure 4. Strainer Housing Removal.
Figure 6. Strainer Housing Installation.
Figure 8. Strainer Housing Installation.
Figure 10. Strainer Housing Installation.
INLET VALVE AND HOSE REPLACEMENT
Figure 2. Inlet Valve and Hose Removal.
Figure 4. Inlet Valve and Hose Installation.
Figure 6. Inlet Valve and Hose Installation.
DIAL POINTER REPLACEMENT
Figure 2. Dial Pointer Installation.
FOLDING HAND RAIL ASSEMBLY REPLACEMENT
Figure 1. Folding Hand Rail Assembly Removal.
Figure 3. Folding Hand Rail Disassembly.
Figure 5. Folding Hand Rail Disassembly.
Figure 7. Folding Hand Rail Disassembly.
Figure 9. Folding Hand Rail Assembly.
Figure 11. Folding Hand Rail Assembly.
Figure 13. Folding Hand Rail Installation.
Figure 14. Folding Hand Rail Installation.
DIAL POINTER SWITCH REPLACEMENT
Figure 2. Dial Pointer Switch Installation.
HIGH TANK LEVEL SWITCH REPLACEMENT
Figure 2. High Tank Level Switch Removal.
Figure 4. High Tank Level Switch Installation.
DIAL AND MOUNTING PLATE REPLACEMENT
Figure 2. Dial and Mounting Plate Installation.
LOW TANK LEVEL SWITCH REPLACEMENT
Figure 2. Low Tank Level Switch Removal.
Figure 4. Low Tank Level Switch Installation.
MANHOLE COVER AND BRACKET REPLACEMENT
Figure 2. Manhole Cover and Bracket Removal.
Figure 4. Manhole Cover and Bracket Removal.
Figure 6. Manhole Cover and Bracket Installation.
Figure 8. Manhole Cover and Bracket Installation.
Figure 10. Manhole Cover and Bracket Installation.
TANK WALKWAY REPLACEMENT
TANK WALKWAY REPLACEMENT - Continued
TANK WALKWAY REPLACEMENT - Continued
VENT SCREEN REPLACEMENT
Figure 2. Vent Screen Installation.
WATER TANK MOUNT BUSHINGS AND SPRING REPLACEMENT
WATER TANK MOUNT BUSHINGS AND SPRING REPLACEMENT - Continued
Figure 2. Water Tank Mount Bushings and Spring Removal.
Figure 4. Water Tank Mount Bushings and Spring Removal.
Figure 6. Water Tank Mount Bushings and Spring Removal.
Figure 7. Water Tank Mount Bushings and Spring Removal.
Figure 8. Water Tank Mount Bushings and Spring Removal.
Figure 9. Water Tank Mount Bushings and Spring Installation.
Figure 11. Water Tank Mount Bushings and Spring Installation.
Figure 12. Water Tank Mount Bushings and Spring Installation.
Figure 14. Water Tank Mount Bushings and Spring Installation.
WATER TANK MOUNT BUSHINGS AND SPRING REPLACEMENT - Continued
VALVE COVER PLATE REPLACEMENT
Figure 2. Valve Cover And Gasket Installation.
WATER TANK REPLACEMENT
Figure 1. Water Tank Removal.
Figure 3. Water Tank Removal.
Figure 5. Water Tank Removal.
Figure 6. Water Tank Removal.
Figure 8. Water Tank Removal.
Figure 10. Water Tank Installation.
Figure 12. Water Tank Installation.
Figure 13. Water Tank Installation.
Figure 15. Water Tank Installation.
Figure 17. Water Tank Installation.
WATER PUMP OIL SERVICE
Figure 1. Water Pump Oil Service.
Figure 2. Water Pump Oil Service.
Figure 3. Water Pump Oil Service.
DIAL INDICATOR ADJUSTMENT
Figure 2. Dial Indicator Adjustment.
Table 1. Dial Indicator Adjustment - Continued.
Table 1. Dial Indicator Adjustment - Continued.
Table 1. Dial Indicator Adjustment - Continued.
WATER PUMP ASSEMBLY REPLACEMENT
Figure 2. Water Pump Assembly Removal.
Figure 3. Water Pump Assembly Removal.
Figure 5. Water Pump Assembly Removal.
Figure 6. Water Pump Assembly Installation.
Figure 7. Water Pump Assembly Installation.
Figure 8. Water Pump Assembly Installation.
Figure 9. Water Pump Assembly Installation.
Figure 10. Water Pump Assembly Installation.
DISCHARGE TUBE AND PIPE ASSEMBLY PUMP OUTLET HOSE REPLACEMENT
Figure 2. Discharge Tube and Discharge Tube and Pipe Assembly Pump Outlet Hose Removal
Figure 4. Discharge Tube and Pipe Assembly Pump Outlet Hose Removal.
Figure 6. Discharge Tube and Pipe Assembly Pump Outlet Hose Removal.
Figure 8. Discharge Tube and Pipe Assembly Pump Outlet Hose Installation.
Figure 10. Discharge Tube and Pipe Assembly Pump Outlet Hose Installation.
Figure 11. Discharge Tube and Pipe Assembly Pump Outlet Hose Installation.
Figure 12. Discharge Tube and Pipe Assembly Pump Outlet Hose Installation.
Figure 13. Discharge Tube and Pipe Assembly Pump Outlet Hose Installation.
PUMP DRIVE COUPLING REPLACEMENT
Figure 2. Pump Drive Coupling Removal
Figure 4. Pump Drive Coupling Installation
SUCTION TUBE AND HOSE REPLACEMENT
Figure 2. Suction Tube and Hose Removal.
Figure 4. Suction Tube and Hose Installation.
HOSE REEL REPLACEMENT
Figure 2. Hose Reel Removal.
Figure 3. Hose Reel Installation.
HOSE REEL REPLACEMENT - Continued
HOSE REEL HOSE REPLACEMENT
Figure 2. Hose Reel Hose Removal.
Figure 4. Hose Reel Hose Installation.
HOSE REEL GUIDE ROLLER ASSEMBLY REPLACEMENT
Figure 2. Hose Reel Guide Roller Assembly Installation.
CAB CONTROL BOX FACEGUARD REPLACEMENT
Figure 2. Cab Control Box Faceguard Replacement.
CAB CONTROL BOX WIRE HARNESS REPLACEMENT
Figure 2. Cab Control Box Wiring Harness Removal.
Figure 4. Cab Control Box Wiring Harness Installation.
DISC MAGNET AND BRACKET REPLACEMENT
Figure 2. Cab Control Mounting Plate Removal.
Figure 3. Cab Control Mounting Plate Installation.
DISC MAGNET AND BRACKET REPLACEMENT - Continued
CAB CONTROL BOX ENGINE START/STOP SWITCH REPLACEMENT
Figure 2. Cab Control Box Engine Start/Stop Switch Installation.
CAB CONTROL BOX WATER SPRINKLER SWITCH REPLACEMENT
Figure 2. Cab Control Box Right Water Sprinkler Switch Removal.
Figure 4. Cab Control Box Water Sprinkler Switch Installation.
Figure 6. Cab Control Box Water Sprinkler Switch Installation.
CAB CONTROL BOX LIGHT SWITCH REPLACEMENT
Figure 2. Cab Control Box Light Switch Installation.
CAB CONTROL BOX ENGINE SPEED RESUME/IDLE SWITCH REPLACEMENT
Figure 2. Cab Control Box Engine Speed Resume/Idle Switch Removal.
Figure 4. Cab Control Box Engine Speed Resume/Idle Switch Installation.
CAB CONTROL BOX ENGINE SPEED RPM SWITCH REPLACEMENT
Figure 2. Cab Control Box Engine Speed RPM Switch Removal.
Figure 4. Cab Control Box Engine Speed RPM Switch Removal.
CAB CONTROL BOX ENGINE SPEED SET BUTTON REPLACEMENT
Figure 2. Cab Control Box Engine Speed Set Button Installation.
CAB CONTROL BOX WATER LEVEL INDICATOR REPLACEMENT
Figure 2. Cab Control Box Water Level Indicator Removal.
Figure 3. Cab Control Box Water Level Indicator Installation.
CAB CONTROL BOX WATER LEVEL INDICATOR REPLACEMENT - Continued
CAB CONTROL BOX ENGINE OFF/BATTERY DRAIN INDICATOR REPLACEMENT
Figure 2. Cab Control Box Engine Off/Battery Drain Indicator Installation.
CAB CONTROL BOX ENGINE OFF/BATTERY DRAIN INDICATOR REPLACEMENT - Continued
CAB CONTROL BOX TACHOMETER REPLACEMENT
Figure 2. Cab Control Box Tachometer Removal.
Figure 4. Cab Control Box Tachometer Removal.
Figure 5. Cab Control Box Tachometer Removal.
Figure 6. Cab Control Box Tachometer Installation.
Figure 7. Cab Control Box Tachometer Installation.
Figure 8. Cab Control Box Tachometer Installation.
Figure 10. Cab Control Box Tachometer Installation.
PREPARATION FOR STORAGE OR SHIPMENT
PREPARATION FOR STORAGE OR SHIPMENT - Continued
PREPARATION FOR STORAGE OR SHIPMENT - Continued
PREPARATION FOR STORAGE OR SHIPMENT - Continued
TORQUE LIMITS
Figure 1. Torque Wrench Formula.
Table 2. Torque Limits - SAE Standard Fasteners.
Table 2. Torque Limits - SAE Standard Fasteners - Continued.
Table 3. Torque Limits - Metric Fasteners.
Table 4. Thread Classes and Description.
CHAPTER 5. REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL)
FIELD MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST
Table 2. Source Code 1st and 2nd Positions
Table 2. Source Code 1st and 2nd Positions - Continued
Table 4. Maintenance Code 4th Position
Table 5. Recoverability Code 5th Position
REPAIR PARTS AND SPECIAL TOOLS LIST
Figure 4002. Water Tank. (Sheet 1 of 3)
Figure 4002. Water Tank. (Sheet 2 of 3)
Figure 4002. Water Tank. (Sheet 3 of 3)
Figure 4002. Water Tank - Continued
Figure 4002. Water Tank - Continued
Figure 4003. Flatrack.
Figure 4003. Flatrack - Continued
Figure 4004. Hoses.
Figure 4004. Hoses - Continued
Figure 4005. Fuel Tank.
Figure 4005. Fuel Tank - Continued
Figure 4006. Stowage Box. (Sheet 1 of 2)
Figure 4006. Stowage Box. (Sheet 2 of 2)
Figure 4006. Stowage Box - Continued
Figure 4007. Pipes. (Sheet 1 of 4)
Figure 4007. Pipes. (Sheet 2 of 4)
Figure 4007. Pipes. (Sheet 3 of 4)
Figure 4007. Pipes. (Sheet 4 of 4)
Figure 4007. Pipes - Continued
Figure 4007. Pipes - Continued
Figure 4008. Cab Control Box. (Sheet 1 of 2)
Figure 4008. Cab Control Box. (Sheet 2 of 2)
Figure 4008. Cab Control Box - Continued
Figure 4009. Battery Box Assembly.
Figure 4009. Battery Box Assembly - Continued
Figure 4010. Engine Pump Module.
Figure 4010. Engine Pump Module - Continued
Figure 4011. Engine - Water Pump.
Figure 4011. Engine - Water Pump. - Continued
Figure 4011. Engine - Water Pump - Continued
Figure 4013. Engine - Pump Lights.
Figure 4013. Engine - Pump Lights - Continued
Figure 4014. Engine - Pump Rear Piping. (Sheet 1 of 5)
Figure 4014. Engine - Pump Rear Piping. (Sheet 2 of 5)
Figure 4014. Engine - Pump Rear Piping. (Sheet 3 of 5)
Figure 4014. Engine - Pump Rear Piping. (Sheet 4 of 5)
Figure 4014. Engine - Pump Rear Piping. (Sheet 5 of 5)
Figure 4014. Engine - Pump Rear Piping - Continued
Figure 4014. Engine - Pump Rear Piping - Continued
Figure 4014. Engine - Pump Rear Piping - Continued
Figure 4014. Engine - Pump Rear Piping - Continued
Figure 4016. Engine - Pump Frame.
Figure 4016. Engine - Pump Frame - Continued
Figure 4017. Fire Extinguisher.
Figure 4017. Fire Extinguisher - Continued
Figure 4018. Engine - Pump Control Box. (Sheet 1 of 3)
Figure 4018. Engine - Pump Control Box. (Sheet 2 of 3)
Figure 4018. Engine - Pump Control Box. (Sheet 3 of 3)
Figure 4018. Engine - Pump Control Box - Continued
Figure 4018. Engine - Pump Control Box - Continued
Figure 4018. Engine - Pump Control Box - Continued
Figure 4020. Engine Assembly. (Sheet 1 of 2)
Figure 4020. Engine Assembly. (Sheet 2 of 2)
Figure 4020. Engine Assembly - Continued
Figure 4021. Air cleaner.
Figure 4021. Air cleaner - Continued
Figure 4022. Coolant Recovery Tank.
Figure 4022. Coolant Recovery Tank - Continued
Figure 4023. Engine Enclosure.
Figure 4023. Engine Enclosure - Continued
Figure 4024. Engine and Mounts.
Figure 4024. Engine and Mounts - Continued
Figure 4025. Exhaust Muffler.
Figure 4025. Exhaust Muffler - Continued
Figure 4026. Instruments and Controls. (Sheet 1 of 4)
Figure 4026. Instruments and Controls. (Sheet 2 of 4)
Figure 4026. Instruments and Controls. (Sheet 3 of 4)
Figure 4026. Instruments and Controls. (Sheet 4 of 4)
Figure 4026. Instruments and Controls - Continued
Figure 4026. Instruments and Controls - Continued
Figure 4027. Radiator.
Figure 4027. Radiator - Continued
Figure 4029. Pump Housing. (Sheet 1 of 2)
Figure 4029. Pump Housing. (Sheet 2 of 2)
Figure 4029. Pump Housing - Continued
Figure 4030. Head Cover.
Figure 4030. Head Cover - Continued
Figure 4031. Cylinder Head.
Figure 4031. Cylinder Head - Continued
Figure 4032. Fuel Filter.
Figure 4032. Fuel Filter - Continued
Figure 4033. Flywheel Assembly.
Figure 4033. Flywheel Assembly - Continued
Figure 4034. Engine Oil Pan.
Figure 4034. Engine Oil Pan - Continued
Figure 4035. Fuel Pump.
Figure 4035. Fuel Pump - Continued
Figure 4036. Water Pump.
Figure 4036. Water Pump - Continued
Figure 4037. Starter.
Figure 4037. Starter - Continued
Figure 4038. Engine Fan.
Figure 4038. Engine Fan - Continued
Figure 4039. Inlet Manifold.
Figure 4039. Inlet Manifold - Continued
Figure 4040. Exhaust Manifold.
Figure 4040. Exhaust Manifold - Continued
Figure 4041. Main Bearing Case.
Figure 4041. Main Bearing Case - Continued
Figure 4042. Dipstick Assembly.
Figure 4042. Dipstick Assembly - Continued
Figure 4043. Alternator and Pulley.
Figure 4043. Alternator and Pulley - Continued
Figure 4044. Oil Cooler.
Figure 4044. Oil Cooler - Continued
Figure 4045. Water Flange and Thermostat.
Figure 4045. Water Flange and Thermostat - Continued
Figure 4046. Nozzle Holder and Glow Plug.
Figure 4046. Nozzle Holder and Glow Plug - Continued
Figure 4047. Engine - Pump Reel. (Sheet 1 of 2)
Figure 4047. Engine - Pump Reel. (Sheet 2 of 2)
Figure 4047. Engine - Pump Reel - Continued
Figure 4049. Walkway. (Sheet 1 of 2)
Figure 4049. Walkway. (Sheet 2 of 2)
Figure 4049. Walkway - Continued
Figure 4050. Dataplates.
Figure 4050. Dataplates - Continued
Figure BULK. Bulk Items.
Figure BULK. Bulk Items - Continued
Figure KITS. Repair Kits.
Figure KITS. Repair Kits. - Continued
Figure TOOL. Special Tools.
Figure TOOL. Special Tools. - Continued
CHAPTER 6. SUPPORTING INFORMATION
REFERENCES
REFERENCES - Continued
MAINTENANCE ALLOCATION CHART (MAC) INTRODUCTION
MAINTENANCE ALLOCATION CHART (MAC) INTRODUCTION - Continued
MAINTENANCE ALLOCATION CHART (MAC) INTRODUCTION - Continued
MAINTENANCE ALLOCATION CHART (MAC) INTRODUCTION - Continued
MAINTENANCE ALLOCATION CHART (MAC) INTRODUCTION - Continued
Table 1. MAINTENANCE ALLOCATION CHART (MAC)
Table 1. MAINTENANCE ALLOCATION CHART (MAC) - Continued
Table 1. MAINTENANCE ALLOCATION CHART (MAC) - Continued
Table 1. MAINTENANCE ALLOCATION CHART (MAC) - Continued
Table 1. MAINTENANCE ALLOCATION CHART (MAC) - Continued
Table 1. MAINTENANCE ALLOCATION CHART (MAC) - Continued
Table 1. MAINTENANCE ALLOCATION CHART (MAC) - Continued
Table 1. MAINTENANCE ALLOCATION CHART (MAC) - Continued
Table 1. MAINTENANCE ALLOCATION CHART (MAC) - Continued
Table 2. TOOLS AND TEST EQUIPMENT REQUIREMENTS
Table 2. TOOLS AND TEST EQUIPMENT REQUIREMENTS - Continued
EXPENDABLE/DURABLE ITEMS LIST
Table 1. Expendable/Durable Supplies and Materials List
Table 1. Expendable/Durable Supplies and Materials List - Continued
Table 1. Expendable/Durable Supplies and Materials List - Continued
Table 1. Expendable/Durable Supplies and Materials List - Continued
Table 1. Expendable/Durable Supplies and Materials List - Continued
TOOL IDENTIFICATION LIST
Table 1. Tool Identification List - Continued.
MANDATORY REPLACEMENT PARTS
Table 1. Mandatory Replacement Parts List - Continued.
Table 1. Mandatory Replacement Parts List - Continued.
Table 1. Mandatory Replacement Parts List - Continued.
Table 1. Mandatory Replacement Parts List - Continued.
Table 1. Mandatory Replacement Parts List - Continued.
SCHEMATICS

Western Governors University

Privacy Statement
Press Release
Contact

Integrated Publishing, Inc. - A (SDVOSB) Service Disabled Veteran Owned Small Business