Google+
Facebook
LinkedIn
Twitter
Digg
StumbleUpon
Home
Download PDF
Order CD-ROM
Order in Print
Figure 1. Centrifugal pump, left side view, with panels open.
Figure 2. Centrifugal pumps right side New, with panels open.
Figure 3. Centrifugal pump, left rear view.
Figure 4. Centrifugal pump, right front view.
Figure 5. Wiring Diagram
Figure 6. Base plan.
Figure 7. Pump readied for shipment.
Figure 8. Areas of pump from which packing must be removed.
Figure 10. Areas of pump requiring servicing.
Section II. CONTROLS AND INSTRUMENTS
Figure 11. Controls and instruments.
Section III. OPERATION UNDER USUAL CONDITIONS
Figure 12. Staring procedure.
Figure 13. Stopping procedure.
Dusty or Sandy Areas
Chapter 3. OPERATOR AND ORGANIZATIONAL MAINTENANCE INSTRUCTIONS
Figure 14. Lubrication order.
Figure 14. Lubrication order. - Continued
Section II. PREVENTIVE MAINTENANCE SERVICES
Figure 16. Daily preventive maintenance services.
Figure 16. Daily preventive maintenance services. - Continued
Figure 16. Quarterly preventive maintenance services.
Figure 16. Quarterly preventive maintenance services. - Continued
Section III. TROUBLESHOOTING
Section IV. RADIO INTERFERENCE SUPPRESSION
Section V. FUEL SYSTEM
Fuel Pump
Figure 18. Carburetor installation.
Figure 19. Air cleaner.
Figure 30. Governor and magneto installation.
Fuel Primer Pump
Figure 22. Fuel tank, lines, and fittings.
Section VI. ENGINE SYSTEM
Figure 24. Generator test circuit.
Figure 26. Generator regulator with cover removed, showing adjusting points.
Figure 27. Generator regulator test setup.
Figure 88. Starting motor and solenoid installation.
Figure 29. Starting motor and solenoid testing circuits.
Figure 31. Magneto point adjustment.
Figure 32. Coolant piping, exploded view.
Figure 33. Testing thermostat.
Section VIII. LUBRICATION SYSTEM
Figure 86. Oil filter.
Figure 87. Lubricating oil lines and fittings.
Figure 88. Valve tappet adjustment.
Figure 39. Exhaust system parts, exploded view.
Figure 40. Air preheater parts, exploded view.
Tachometer and Hourmeter
Battery Disconnect Switch
Figure 41. Hood and side panels, exploded view.
Figure 42. Lines and fittings.
Section XII. DISCHARGE AND INTAKE PRESSURE LINES
Section I. ENGINE REPAIR AND REPLACEMENT STANDARDS
Table III. Engine Repair and Replacement Standards-Continued
Disassembly
Figure 44. Pump installation.
Figure 46. Stub shaft and drive, exploded view.
Dash
Figure 47. Governor, exploded view.
Section IV. ENGINE ELECTRICAL SYSTEM
Figure 48. Generator, exploded view.
Starting Motor Repair
Figure 49. Starting motor, exploded view.
Figure 50. Generator regulator, exploded view.
Figure 51. Voltage regulator, exploded view.
Figure 53. Cutout relay, exploded view.
Figure 54. Magneto, exploded view.
Figure 65. W ater pump, exploded view.
Figure 56. External engine parts, exploded view.
Water Pump Repair
Figure 57. Checking cylinder head flatness.
Figure 59. Valves, camshaft, and oil pump, exploded view.
Valve and Valve Tappets
Figure 62. Pulling valve seat insert.
Oil Pan and Filler Blocks
Figure 65. Installing neoprene seal in front filer block
Figure 67. Checking oil pump end clearance.
Figure 68. Crankshaft, pistons, and connecting rods, exploded view.
Figure 69. Checking bearing clearance using plastigage
Figure 71. Checking flywheel housing eccentricity.
Figure 72. Checking gear clearance
Crankshaft, Crankshaft Bearings, and Camshaft
Figure 73. Removing bearing with angular-headed pin
Section VII. PUMP REPAIR
Figure 74. Pump, exploded view.
Impeller, Shaft, Seal and Bearings
Section VIII. SKID BASE AND RELATED PARTS
INDEX TO FIGURE 75
Figure 75. Skid base and related parts, exploded view.
REFERENCES
REFERENCES - Continued
BASIC ISSUE ITEMS LIST AND MAINTENANCE AND OPERATING SUPPLIES
Section II. BASIC ISSUE ITEMS LIST
Section II. BASIC ISSUE ITEMS LIST - Continued
Section III. MAINTENANCE AND OPERATING SUPPLIES
Appendix III. MAINTENANCE ALLOCATION CHART
Section II. MAINTENANCE ALLOCATION CHART
Section III. SPECIAL TOOL AND SPECIAL TEST EQUIPMENT REQUIREMENTS
Integrated Publishing, Inc. - A (SDVOSB) Service Disabled Veteran Owned Small Business
