TM 10-4320-344-24
taped or strapped to the trailer, between the pump and the engine. Retrieve the
muffler and any other components taped or strapped to it. Install the muffler in
accordance with paragraph 2.13.3.
2.5 INSTALLATION INSTRUCTIONS.
Refer to applicable TWDS technical manual for pumping assembly installation
i n s t r u c t i o n s.
2.6 PRELIMINARY SERVICING AND ADJUSTMENT OF EQUIPMENT.
Crankcase is filled to operating level with preservative oil, MIL-P-21260.
Engine lubricating preservation oil does not have to be drained from
crankcase until first scheduled oil change.
a.
Check engine crankcase oil level. Service as required (refer to
LO 10-4320-344-12).
b.
Fill fuel tank with proper grade fuel.
Do not fill battery without rubber gloves and protective clothing.
Electrolyte causes serious burns. Failure to obey this warning may result in
personal injury or death.
c .
If batteries were shipped dry, remove and fill with electrolyte to a
level 3/8 inch (9.5 mm) above cell plates.
d.
Refer to paragraph 2.15.2 for Model 609-A, paragraph 2.15.3 for Model
609-C, and paragraph 2.15.4 for Model US636HCCD-1 and install batteries,
attach cables, and cover.
e.
Service tires to 40 psi (276 kPa).
f .
Refer to paragraph 2.21.13 and adjust alternator belt.
2.7 PUMPING ASSEMBLY LUBRICATION.
Refer to LO 10-4320-344-12 for lubrication instructions.
SECTION III. UNIT PREVENTIVE MAINTENANCE
CHECKS AND SERVICES (PMCS)
2.8 GENERAL.
Tables 2-1, 2-2 and 2-3 (PMCS tables) have been provided so you can keep your
equipment in good operating condition and ready for its primary mission.
2.8.1 Warnings and Cautions.
Always observe the WARNINGS and CAUTIONS appearing in
your PMCS table. Warnings and cautions appear before applicable procedures.
Observe these W A R N I N G S to prevent serious injury to yourself and others, and the
CAUTIONS to prevent your equipment from being damaged.
2.8.2 Reporting Deficiencies.
Report any deficiencies using the proper forms. See DA
PAM 738-750, TAMMS.
2.8.3 Removing Assemblies or Equipment.
If the PMCS table requires removal of assemblies
or equipment, refer to the maintenance paragraph listed.
2-5
NOTE
