L05-4320-237-12
LUBRICATION ORDER
10 JUNE 1977
(Supersedes LO5-4320-237-15, 5 MAY 1967)
PUMPING ASSEMBLY, FLAMMABLE LIQUID,
BULK TRANSFER, CENTRIFUGAL,
50 GPM, 100 FOOT HEAD: GASOLINE ENGINE DRIVEN, 2 IN.
FRAME MOUNTED, (BARNES MODEL-QM-2-28002)
WITH WISCONSIN ENGINE MODEL-MBKND,
SPECIFICATION 279315
Reference: C9100-IL
equipment. Clean parts with SOLVENT, dry cleaning,
Intervals and related task-hour times are based on nor-
or with OIL, fuel, diesel. Dry before lubricated. Drain
mal hours of operation. The task-hour time specified is
crankcase when HOT. Fill and check level. The lowest
the time you need to do all the services prescribed for a
level of maintenance authorized to lubricate a point is
particular interval. Change the interval if your lubri-
indicated by one of the following: (C) operator/crew, or
cants are contaminated or if you are operating the
(0) organizational maintenance.
equipment under adverse operating conditions, includ-
ing longer-than-usual operating hours. You may extend
You can improve this publication by calling attention to
the interval during periods of low activity, but you must
errors and by recommending improvements and by stat-
take adequate preservation precautions.
ing your reasons for the recommendations. Your letter
*The time specified is the time required to perform all
or DA Form 2028 (Recommended Changes to Publica-
services at the particular interval.
tions and Forms) should be mailed directly to Com-
Clean fittings before lubricating. Relubricate all areas
mander, U. S. Army Troop Support Command, ATTN:
exposed to water after amphibious operation. Lubricate
DRSTS-MPP, 4300 Goodfellow Blvd., St. Louis, MO
points indicated by dotted arrow shaft on both sides of
63120. A reply will be furnished directly to you.
FOLD
FOLD
LUBRICANT
INTERVAL
LUBRICANT
INTERVAL
q
q
I
Air
Cleaner
OE
D
w
Crankcase Drain
Plug
(Refill oil reservoir to level
(Drain and refill)
mark; every 25 hours, 250
miles, or weekly, disassem-
ble entire unit; clean, reoil
D
Crankcase Fill Plug (Check
OE
and reassemble.)
Level)
(See Note 2.)
(See Key)
*TOTAL TASK HOURS
*TOTAL TASK HOURS
INTERVAL
INTERVAL
TASK-HOURS
TASK-HOURS
1.5
D
W
0.5
CARD 1 OF 2
